膜科学与技术

位置：首页 >> 期刊内容阅读

荷电微孔陶瓷膜在应急饮水净化中的应用研究

作者：朱孟府，邓橙，宿红波，游秀东，陈平

单位：军事医学科学院卫生装备研究所, 天津 300161

关键词：荷电微孔膜；陶瓷膜；饮水净化；膜分离；应急救援

DOI号：

分类号： X52； TQ129

出版年,卷(期):页码： 2013,33(3):1-4

摘要：

以氧化镁和氧化钇为荷电剂，通过浸渍烧结工艺制备带正电荷微孔陶瓷膜，可通过筛分截留和正负电荷吸引作用吸附分离水中污染物。结果显示，荷电微孔陶瓷膜对水中微粒和微生物有很好的去除效果，净水浊度小于1.0 NTU，孔径大于0.45 μm膜的细菌总数去除率大于99.9%，净水中未检测出大肠杆菌，不同孔径膜的大肠杆菌噬菌体f2去除率均可达100%，细菌内毒素去除率大于99%。荷电微孔陶瓷膜具有良好的机械强度和净水效果，可用于应急饮水净化。

Using magnesium oxide and yttrium oxide as positive charged agents, the charged microporous ceramic membrane was prepared by impregnation and sintering process, which could separate pollutant in water through sieving and electrostatic adsorption. The results showed that the charged microporous ceramic membrane had a good removal effect on particulate and microbe in natural water. The turbidity of purified water was less than 1.0 NTU. The removal rate of total number of colonies was greater than 99.9%, while E. coli was not detected in purified water. The removal rate of coliphages f2 by charged microporous ceramic membrane with different pore sizes can reach 100%, and the removal rate of bacterial endotoxin was larger than 99%. Therefore, charged microporous ceramic membrane had good mechanical strength and water purification effect, which could be used for emergency water purification.

基金项目：

国家自然科学基金资助项目（51202292）

作者简介：

朱孟府（1965－），男，博士，研究员；研究方向为膜分离水处理技术与装备；E-mail: zmf323@163.com

参考文献：

[1]朱孟府，龚承元，苏建勇，等. 野战班用净水器的研制[J]. 医疗卫生装备,2004,25(7):18-19.
[2]朱孟府，龚承元，苏建勇，等. 野战排用净水机的研制[J]. 医疗卫生装备,2006,27(9):15-16.
[3]Wegmann M, Michen B, Luxbacher T, et al. Modification of ceramic microfilters with colloidal zirconia to promote the adsorption of viruses from water[J]. Water Res., 2008, 42:1726-1734.
[4]Wegmann M, Michen B, Graule T. Nanostructured surface modification of microporous ceramics for efficient virus filtration[J]. J. Eur. Ceram. Soc., 2008, 28:1603-1612.
[5]Borrego J J, Cornax R, Preston D R, et al. Development and application of new positively charged filters for recovery of bacteriophages from water. Applied and Environmental Microbiology[J], 1991,57(4):1218-1222.
[6]朱孟府，龚承元，苏建勇，等. 荷电滤板的吸附分离性能评价[J]. 水处理技术, 2006,32（1）：80-82
[7]中华人民共和国国家标准. GB/T5749-2006，生活饮用水卫生标准[S].2006.
[8]生活饮用水卫生规范，中华人民共和国卫生部，卫法监发[2001]161号，2001.
[9]朱孟府，龚承元，苏建勇，等. 浸涂法荷电微孔滤膜基本结构及性能[J]. 膜科学与技术，2006,26(5):105-108.
[10]朱孟府，龚承元，苏建勇，等. 荷正电微孔滤器除水中细菌的研究[J]. 军事医学科学院院刊, 2007,31(6):535-537.
[11]Ikner L A, Soto-Beltran M, Bright K R. New method using a positively charged microporous filter and ultrafiltration for concentration of viruses from tap water[J]. Appl. Environ. Microbiol., 2011, 77(10):3500-3506.
[12]Michen B, Graule T. Isoelectric points of viruses[J]. J. Appl. Microbiol., 2010, 109(2):388-397.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com