膜科学与技术

位置：首页 >> 期刊内容阅读

国产纳滤膜淡化高氟苦咸水基础研究

作者：胥璐¹，²，姜雯丽¹，²，王剑¹，²，高学理¹，²

单位： 1．中国海洋大学海洋化学理论与工程技术教育部重点实验室，山东青岛 266100；

关键词：国产纳滤膜；脱氟；苦咸水淡化

DOI号：

分类号： TQ028.8

出版年,卷(期):页码： 2015,35(1):108-114

摘要：

实验选取两种国产纳滤膜NF2A和NF3A进行纳滤膜淡化高氟苦咸水的基础研究，考察操作压力、温度、进水pH、进水氟浓度、总含盐量及运行时间对纳滤膜分离性能的影响，并测定膜的Zeta电位，同时简单比较两种膜。研究结果表明，两种纳滤膜处理高氟苦咸水的理想操作条件为：压力1.0～1.5MPa，温度20℃，进水pH=6.5左右，在此条件下NF3A纳滤膜的脱盐率为79%，脱氟率为90%，产水通量为53 L·m-2·h-1，NF2A纳滤膜分别为73%，73%和71 L·m-2·h-1，此外随进水氟浓度和总含盐量的增大，纳滤膜的脱氟和脱盐率降低，同时得出两种膜在长期运行72 h内膜性能基本保持稳定，最后测得NF3A和NF2A的Zeta电位分别为-22和-18 mV。这项研究为国产纳滤膜处理高氟苦咸水的实际应用提供了技术数据，有利于国产纳滤膜的发展和完善。

In this study,the performances of two domestic NF membranes (NF2A and NF3A) for defluorinating brackish water with high fluoride were studiedand compared.And the influences of pressure, temperature, pH,fluoride concentration, total dissolved solids and running time were studied by a pilot unit test.And the Zeta potential of the two NF membranes was detected.Then the optimum condition was identified as followings: Pressure 1.0-1.5MPa, Temperature 20℃, pH=6.5.Under this condition,the desalination rate, the defluorination rate and the water flux of NF3A membrane was 79%, 90% and 53 L·m-2·h-1, while that of the NF2A membrane was 73%,73% and 71L·m-2·h-1, respectively.And as a result of the increasing of fluoride concentration and TDS, the defluorination ratedecreased. Meanwhile,the results of long-term operation (72h) showed that the permeability of the membrane remained stable. Finally, the Zeta potential of NF3A and NF2A was -22 and -18 mV. This research will provide technical references to the practical application of domestic NF membranes in the treatment of brackish water, and promote and improve the development of domestic NF membranes.

基金项目：

高通量纳滤膜材料的规模化制备技术(2012AA03A602)；MBR-NF处理世园会园区污水回用技术(12-1-3-56-nsh)

作者简介：

胥璐，1990年，女，山东省莱芜市，硕士研究生，纳滤膜水处理。通讯作者：E-mail: gxl_ouc@126.com

参考文献：

[1]戴向前, 刘昌明, 李丽娟.我国农村饮水安全问题探讨与对策 [J].地理学报, 2007, 62(9):907-916.
[2]朱其顺, 许光泉.中国地下水氟污染的现状及研究进展 [J].环境科学与管理, 2009, 34(1):42-44+51.
[3]Diawara CK.,Lo SM, Rumeau M, et al. A phenomenological mass transfer approach in nanofiltration of halide ions for a selective defluorination of brackish drinking water [J]. Journal of Membrane Science, 2003,219(1–2):103-112.
[4]栾韶华, 孙国瑞, 王奇.苦咸水淡化技术综述 [J].四川环境, 2010,29(1):97-99+105.
[5]李雪玲,刘俊峰,李培元.石灰沉淀法除氟的应用 [J].水处理技术,2000,26(6):359-361.
[6]董岁明.氟在土—水系统中的迁移机理与含氟水的处理研究 [D].长安:长安大学, 2004.
[7]Mohapatra M, Anand S, Mishra BK, et al. Review of fluoride removal from drinking water [J]. Journal of Environmental Management, 2009,91(1):67-77.
[8]Wang Hongtao,Chen Jun, Cai Yuanfeng, et al. Defluoridation of drinking water by Mg/Al hydrotalcite-like compounds and their calcined products [J]. Applied Clay Science, 2007,35(1-2):59-66.
[9]Wu Xiaomei,Zhang Yu, Dou Xiaomin, et al. Fluoride removal performance of a novel Fe-Al-Ce trimetal oxide adsorbent [J]. Chemosphere, 2007,69(11):1758-1764.
[10]Chevereau E, Limousy L,Dutournie P. Use of Mordenite Surface Acidity Properties for the Selective Separation of Halide Salts: Modification of Dielectric Effects [J]. Industrial & Engineering Chemistry Research, 2011,50(7):4003-4010.
[11]戴喆男,周勇,赵婷,等.饮用水及含氟废水处理技术机理及研究进展 [J].水处理技术, 2012,38(4):7-11+15.
[12]刘训东,杨宏伟,杨小平,等.纳滤膜淡化苦咸水技术现状及进展 [J].净水技术, 2008,27(4):19-21.
[13]Kelewou H.,Lhassani A, Merzouki M, et al. Salts retention by nanofiltration membranes: Physicochemical and hydrodynamic approaches and modeling [J]. Desalination, 2011,277(1–3):106-112.
[14]马准.磺化聚醚砜纳滤膜荷电机理的动电法分析及其截留性能预测 [D].青岛:中国海洋大学, 2010.
[15]王晓琳,张澄洪,赵杰.纳滤膜的分离机理及其在食品和医药行业中的应用 [J].膜科学与技术, 2000,20(1):29-36.
[16]Lhassani A,Rumeau M, Benjelloun D, et al. Selective demineralization ofwater by nanofiltration Application to the defluorination of brackish water. [J]. Water Research, 2001,35(13):3260-3264.
[17]吕建国,王文正.纳滤淡化高氟苦咸水示范工程 [J].给水排水, 2009,35(7):25-27.
[18]王双合,胡兴林,蓝永超,等.甘肃省苦咸水资源量及时空分布规律研究 [J].中国沙漠, 2009,29(5):995-1002.
[19]高从堦,陈益棠.纳滤膜及其应用 [J].中国有色金属学报, 2004,14(1):310-316.
[20]Sharma RR,Chellam S. Temperature and concentration effects on electrolyte transport across porous thin-film composite nanofiltration membranes: Pore transport mechanisms and energetics of permeation [J]. Journal of Colloid and Interface Science, 2006,298(1):327-340.
[21]Pontié M,Diawara CK,Rumeau M. Streaming effect of single electrolyte mass transfer in nanofiltration: potential application for the selective defluorination of brackish drinking waters [J]. Desalination, 2003,151(3):267-274.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com