膜科学与技术

位置：首页 >> 期刊内容阅读

多效膜蒸馏法秸秆酸水解液脱毒及糖浓缩

作者：刘青¹，秦英杰¹，²，刘建军¹，张云¹，刘立强²，崔东胜²

单位： 1.天津大学化工学院，天津，300072；2.洁海瑞泉膜技术有限公司，天津，300300

关键词：多效膜蒸馏；秸秆酸水解液；挥发性组分；葡萄糖；脱毒；浓缩

DOI号：

分类号： TQ028.8

出版年,卷(期):页码： 2015,35(6):87-92

摘要：

秸秆酸水解液含有有毒组分从而影响发酵效率。本文研究了多效膜蒸馏用于模拟秸秆酸水解液中抑制性挥发组分脱除和糖分浓缩，以膜通量J、造水比GOR和葡萄糖截留率Rg为性能指标，考察了冷料液进口温度T1、加热后料液进口温度T3、料液浓度Cf和料液流量Ff的影响。实验结果表明，T1升高时，J下降，而GOR随之升高；T3升高时，J和GOR均随之升高；Cf增加，J和GOR均随之降低；Ff增加，J增加，而GOR随之降低；Rg几乎不受操作条件的影响，始终在99.99%以上。实验过程中最高J可达6.17 L·m-2·h-1，最高GOR可达13.57。对模拟秸秆酸水解液中的甲酸、乙酸、乙酰丙酸、糠醛的脱除率分别达87.76%、90.62%、4.25%、76.52%以上，同时可将水解液中的葡萄糖浓缩14倍以上。该研究结果表明，多效膜蒸馏过程可有效脱除水解液中挥发性组分，同时对糖分进行浓缩。

The aqueous glucose solution obtained from hydrolyzing straws containsformic acid, acetic acid, levulinic acid and furfural which reduce the fermentation efficiency. In this study, multiple-effect membrane distillation (MEMD) process was used to remove these volatile organic species from the simulated hydrolysate and meanwhile enrich the sugar solution. The effects of cold feed-in temperature T1, heated feed-in temperature T3, feed-in concentration Cfand feed-in flow rate Ffwere tested on the performance of MEMD process indicated by permeation flux J, gained-output-ratio (GOR) and rejection rate of glucose Rg. The experimental results showed that J decreased with the increase of T1 while GOR increased; J and GOR both increased with the increase of T3; J and GOR both decreased with the increase of Cf; J increased with the increase of Ff while GOR decreased; Rg was hardly affected by these factors and kept above 99.99% during the whole process. The maximum J and GOR obtained were 6.17 L·m-2·h-1 and 13.57, respectively. The removal rates of formic acid, acetic acid, levulinic acid and furfural were87.76%, 90.62%, 4.25% and 76.52%, respectively, and meanwhile the glucose in the hydrolysate could be concentrated 14 times. This study showed that MEMD process could remove volatile organic species from the hydrolysateand meanwhile enrich the sugar solution effectively.

基金项目：

作者简介：

参考文献：

[1] Limayem A, Ricke S C. Lignocellulosic biomass for bioethanol production: Current perspectives, potential issues and future prospects[J]. Progress in Energy and Combustion Science, 2012, 38: 449-467.
[2] 武冬梅, 李冀新, 孙新纪. 纤维素类物质发酵生产燃料乙醇的研究进展[J]. 酿酒科技, 2007, (4): 116-120.
[3] 于斌, 齐鲁. 木质纤维素生产燃料乙醇的研究现状[J]. 化工进展, 2006, 25(3): 244-249.
[4] 李淑君. 植物纤维水解技术[M]. 北京: 化学工业出版社, 2009. 186-190.
[5] Zhang L, Wang Y F, Cheng L H, et al. Concentration of lignocellulosichydrolyzates by solar membrane distillation[J]. Bioresource Technology, 2012, 123: 382-385.
[6] Chen J W, Zhang Y Q, Wang Y F, et al. Removal of inhibitors from lignocellulosichydrolyzates by vacuum membrane distillation[J]. Bioresource Technology, 2013, 144: 680-683.
[7] 林贝, 赵心清, 葛旭萌, 等. 玉米秸秆酸解副产物对重组酿酒酵母6508-127发酵的影响[J]. 中国生物工程杂志, 2007, 27(7): 61-67.
[8] 赵胜涛. 生物质水解液发酵制乙醇的研究[D]. 上海: 华东理工大学, 2012. 29-34.
[9] 庄军平, 林鹿, 庞春生, 等. 木质纤维稀酸水解液脱毒研究进展[J]. 现代化工, 2009, 29(2): 19-23.
[10] 吴庸烈. 膜蒸馏及其应用进展[J]. 膜科学与技术, 2003, 23(4): 67-79, 92.
[11] 秦英杰, 刘立强, 何菲, 等. 内部热量回收式多效膜蒸馏用于海水淡化及浓盐水深度浓缩[J]. 膜科学与技术, 2012, 32(2) : 52-58.
[12] Yao K, Qin Y J, Yuan Y J, et al. A continuous-effect membrane distillation process based on hollow fiber AGMD module with internal latent-heat recovery. AIChE J., 2013, 59 (4): 1278-1297.
[13] Li X J, Qin Y J, Liu R L, et al. Study on concentration of aqueous sulfuric acid solution by multiple-effect membrane distillation[J]. Desalination, 2012, 307: 34-41.
[14] Liu R L, Qin Y J, Li X J, et al. Concentrating aqueous hydrochloric acid by multiple-effect membrane distillation [J]. Frontiers of Chemical Science and Engineering, 2012, 6 (3): 311-321.
[15] Ban R, Liu M M, Qin Y J, et al. Enrichment of semi-volatile organic acids from aqueous solutions by multiple-effect membrane distillation[J]. Transactions of Tianjin University, 2012, 18 (5): 320-329.
[16] 刘晶, 秦英杰, 王平, 等. 多效膜蒸馏技术用于氢氧化钠稀溶液的浓缩[J]. 工业水处理, 2014, 34 (11): 73-76.
[17] 王平, 秦英杰, 刘晶, 等. 多效膜蒸馏技术用于深度浓缩多种无机盐水溶液[J]. 膜科学与技术, 2014, 34 (4): 39-44.
[18] 王奔, 秦英杰, 王彬, 等. 多效膜蒸馏过程用于海水和浓海水的深度浓缩[J]. 化工进展, 2013, 32 (9): 2233-2241.
[19] Miller G L. Use of Dinitrosalicylic Acid Reagent for Determination of Reducing Sugar[J]. Analytical Chemistry, 1959, 31 (3): 426-428.
[20] Curtis R G, Hatt H H. Equilibria in furfural-water systems under increased pressure and the influence of added salts upon the mutual solubilities of furfural and water[J]. Austr J Sci ResSer A-PhysSci, 1948, 1(2):213-235.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com