膜科学与技术

位置：首页 >> 期刊内容阅读

聚偏氟乙烯再生膜的制备与性能研究

作者：顾维娣，田艺苑，陈莹蕾，任月萍，李秀芬，王新华，夏浩杰，李依航

单位：江苏省厌氧生物技术重点实验室，江苏省水处理技术与材料协同创新中心，江南大学环境与土木工程学院，无锡 214122

关键词：废旧平板膜；聚偏氟乙烯；再生膜；膜性能表征

DOI号：

分类号： TQ028.8

出版年,卷(期):页码： 2016,36(5):47-52

摘要：

本文考察了以MBR生活污水和微电子电镀废水处理工程产生的废旧平板膜表面的PVDF制备再生膜的过程中，废旧PVDF占再生膜铸膜液中总PVDF的比例对再生膜结构和性能的影响．实验发现向铸膜液中掺杂33%从废旧膜面提取得到的PVDF，对再生膜(DS-33和ME-33)铸膜液粘度影响不大，然而将从废旧膜面提取得到的PVDF的掺杂量增大到75%后，再生膜(DS-75和ME-75)铸膜液粘度有所降低，相应DS-75和ME-75的皮层结构致密程度较新膜低．制备得到的再生膜表面的水接触角与新膜相比相差不大，且新膜和再生膜表面均为亲水性表面．以新膜和再生膜运行MBR小试装置，四个再生膜组件的出水COD和NH3-N浓度与新膜膜组件相比相差不大，出水浊度均小于1 NTU．

The influence of the doping amount of the polyvinylidene fluoride (PVDF) extractive from waste flat membranes of domestic swage and electroplating wastewater membrane bioreactor (MBR) engineering into the casting solutions on the structure and performance of the recycled PVDF flat membranes has been investigated in this paper. According to the experiment results, the viscosity of the casting solutions doping 33% PVDF extractive were similar with that of the new membrane casting solution. The viscosity of the casting solutions with 75% PVDF extractive doping amount decreased and the corresponding DS-75 and ME-75 recycled membranes exhibited relatively incompact cortexes compared with the new membrane，the DS-33 and the ME-33 recycled membranes. The water contact angles of the new membrane and the recycled membranes were very similar and the membrane surfaces were all hydrophilic. The performance of the membranes were tested in a small experimental MBR and the COD and NH3-N concentrations in the effluent of the four recycled membranes were almost the same with that of the new membrane. Moreover, the turbidity of the effluent of the membranes were all lower than 1 NTU.

基金项目：

作者简介：

参考文献：

[1] 袁浩歌，马文中，王晓琳．聚偏氟乙烯均聚物和共聚物的结晶行为研究[J]．膜科学与技术，2014，34(1):15-23．
[2] 吴杰，顾维娣，任月萍，等．以废旧聚偏氟乙烯平板膜制备再生膜的研究[J]．膜科学与技术，2015，35(5):79-84．
[3] 王许云，赵书菊，张林，等．聚合物分子量对浸没沉淀法制备PVDF微孔膜结构与结晶的影响[J]．高分子材料科学与工程，2010，26(9):76-79．
[4] Hou Deyin，Fan Hua，Jiang Qinliang，et al．Preparation and characterization of PVDF flat-sheet membranes for direct contact membrane distillation[J]．Separation and Purification Technology，2014，135:211-222．
[5] Oh S J，Kim N，Lee Y T．Preparation and characterization of PVDF/TiO2 organic-inorganic composite membranes for fouling resistance improvement[J]．Journal of Membrane Science，2009，345:13-20．
[6] Hou Deyin，Dai Guohua，Wang Jun，et al．Preparation and characterization of PVDF/ nonwoven fabric flat-sheet composite membranes for desalination through direct contact membrane distillation[J]．Separation and Purification Technology，2012，101:1-10．
[7] 冯昆鹏，袁博，杨慎思，等．次氯酸钠清洗条件对PVDF微滤膜结构的损伤和性能的影响[J]．膜科学与技术，2015，35(3):51-56．
[8] Yu Zongxue，Zeng Guangyong，Pan Yang，et al．Effect of functionalized multi-walled carbon nanotubes on the microstructure and performances of PVDF membranes[J]．RSC Adv．2015，5:75998-76006．
[9] 齐秀聪，王金拉．对称性微孔滤膜平均孔径测量的理论研究[J]．膜科学与技术，1995，1:56-62．
[10] Chang Xiaojing，Wang Zhenxing，Quan Shuai，et al．Exploring the synergetic effects of graphene oxide (GO) and polyvinylpyrrodione (PVP) on poly(vinylylidenefluoride) (PVDF) ultrafiltration membrane performance[J]．Applied Surface Science，2014，316:537-548．
[11] Liu Meitian，Xiao Changfa，Hu, Xiaoyu．Effects of non-solvent additives on PVDF solution viscosity and membrane performance[J]．Iranian polymer journal，2011，20(12):979-988．
[12] Lai J，Sunderland B，Xue J，et al．Study on hydrophilicity of polymer surfaces improved by plasma treatment[J]．Appl Surf Sci．2006，252(10):3375-3379．
[13] Yu H M，Ziegler C，Oszcipok M，et al．Hydrophilicity and hydrophobicity study of catalyst layers in proton exchange membrane fuel cells[J]．Electrochim Acta．2006，51(7):1199-1207．

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com