膜科学与技术

位置：首页 >> 期刊内容阅读

平流式多效真空膜蒸馏过程的实验研究

作者：张永刚，彭跃莲?，纪树兰

单位：北京工业大学环境与能源工程学院北京绿色催化和分离重点实验室, 北京，100124

关键词：平流；多效；真空膜蒸馏；造水比；效间温差

DOI号：

分类号： TQ028.8

出版年,卷(期):页码： 2016,36(6):11-18

摘要：

本文利用疏水性聚四氟乙烯（PTFE）中空纤维膜和PTFE毛细管换热器耦合组成的四效平流式真空膜蒸馏系统（ME-VMD）进行实验研究，重点考察了进料温度、进料流速和透过侧绝对压强对各效的膜通量和热效率及系统的产水量和造水比（GOR）的影响。实验结果表明，ME-VMD系统的效间温差随进料温度的升高而增大，随效数的增大而减小，系统的最佳效数与料液进口温度有直接关系；较高的进料温度、较低的料液流速及尽可能低的透过侧绝对压强均有助于膜通量、产水量及造水比的提高；而热效率则随进料温度的升高而逐步升高，随透过侧绝对压强及料液流速的升高而降低。当进料为温度90℃时，可采用四效真空膜蒸馏；当进料流速为0.30m/s，透过侧绝对压强为3kPa时，其造水比可达到2.15。

An experimental investigation was carried out by using advection multi-effect vacuum membrane distillation (ME-VMD) system containing hydrophobic PTFE hollow fiber membrane and PTFE capillary heat exchanger. The effect of feed temperature, feed velocity and vacuum degree on the transmembrane flux, thermal efficiency and gained-output-ratio (GOR) were investigated. The experimental results show that the temperature difference loss increases with the increase of feed temperature, and decreases with the increase of the effect number. The best effect number has a direct relationship with the feed temperature. High feed temperature, low flow rate and the high vacuum degree contribute to the improvement of transmembrane flux, water yield and GOR. The thermal efficiency increases with the increase of feed temperature and vacuum degree and declines with the increase of feed velocity. When the feed temperature, the feed velocity and the absolute pressure at the permeate side is 90℃, 0.30m/s and 3kPa, respectively, four effect ME-VMD can be used, and the GOR can get to 2.15.

基金项目：

作者简介：

第一作者简介：张永刚（1976-），男，山东德州人，博士研究生，研究方向为膜蒸馏技术及应用，E-MAIL：yongganga@126.com.?通讯作者，E-mail:pyl@bjut.edu.cn

参考文献：

[1] El-Bourawi M S, Ding Z, Ma R, et al. A framework for better understanding membrane distillation separation process [J]. J Membr Sci, 2006, 285 (1-2) :4-29.
[2] Alkhudhiri A, Darwish N, Hilal N. Membrane distillation：A comprehensive review [J]. Desalination, 2012, 287:2-18.
[3] Drioli E,Wu Y.Membrane distillation:an experimental study [M]. Desalination, 1985, 53:339-340.
[4] Lawson K W , Lioyd D R. Membrane distillation [J]. J Membr Sci,1997, 124 (1): 1-25.
[5] 赵晶，武春瑞，吕晓龙.膜蒸馏海水淡化过程研究：三种膜蒸馏过程的比较[J].膜科学与技术，2009,29（1）:83-89.
[6] 张猛，高启君，文晨，吕晓龙.减压多效膜蒸馏过程试验研究 [J]. 水处理技术，2102，38（6）:57-62.
[7] 秦英杰，刘立强，何菲，等.内部热能回收式多效膜蒸馏用于海水淡化及浓盐水深度浓缩[J].膜科学与技术，2012,32（2）:52-57.
[8] Zhang Y, Peng Y, Ji S, et al. Review of thermal efficiency and heat recycling in membrane distillation processes. Desalination, 2015,367, 223-239.
[9] 刘学晶，李保安.减压膜蒸馏热量回收研究[J]. 化学工业与工程, 2012, 3
（2）:38-42.
[10] Camacho L M,Dumée L, Zhang J h , et al. Advances in Membrane Distillation for Water Desalination and Purification Applications [J].Water, 2013, 5, 94-196.
[11 Khayet, M, Membranes and theoretical modeling of membrane distillation: a review [J].Adv Colloid Interface Sci, 2011, 164, 56-88.
[12] Fan H W, Peng Y L. Application of PVDF membranes indesalination and comparison of the VMD and DCMD processes [J].Chemical Engineering Science, 2012,79:94-102.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com