膜科学与技术

位置：首页 >> 期刊内容阅读

乳化液膜去除焦化废水中苯酚的初步研究

作者：焦潇帅，王力，颜冰川，殷景超

单位： 1.山东科技大学安全与环境工程学院，山东青岛 266590；2. 山东科技大学化学与生物工程学院，山东青岛266590

关键词：乳化液膜；苯酚；稳定性；迁移率

DOI号：

分类号： X523

出版年,卷(期):页码： 2020,40(4):119-125

摘要：

本文采用乳化液膜法去除焦化废水中的苯酚，建立了以磷酸三丁酯(TBP)为载体，Span-80为表面活性剂，煤油作膜溶剂及以NaOH溶液为内相的乳化液膜体系。首先采用红外光谱分析手段，测定TBP负载苯酚红外光谱图，通过相应官能团的波数位移变化，得出TBP与酚类物质属氢键缔合。其次通过液膜稳定性实验表明：当表面活性剂浓度为5%、油内比为1:1、制乳时间为30min、制乳转速为2000r/min时，可以得到较为稳定的乳化液膜；最后根据分离实验结果得出：当表面活性剂浓度为5%、搅拌速度为300r/min、油内比为1:1、NaOH溶液浓度为0.5mol/L、分离时间为30min、载体浓度为0.2mol/L、乳水比为1/3时，苯酚的迁移率可达到95%以上。

The emulsion liquid membrane method was used to remove phenol from coking wastewater. An emulsion liquid membrane system was established with tributyl phosphate (TBP) as the carrier, Span-80 as the surfactant, kerosene as the film solvent, and NaOH solution as the internal phase. First, the infrared spectrum analysis method was used to determine the infrared spectrum of TBP-supported phenol. Based on the change of the wave number shift of the corresponding functional group, it was concluded that TBP was hydrogen-bonded with phenols. Liquid film stability experiments show that when the surfactant concentration is 5%, the internal oil ratio is 1:1, the milking time is 30min, and the milking speed is 2000r/min, a more stable emulsion film can be obtained; separation experiment The results show that when the surfactant concentration is 5%, the stirring speed is 300r/min, the oil ratio is 1:1, the NaOH solution concentration is 0.5mol/L, the separation time is 30min, the carrier concentration is 0.2mol/L, the milk When the water ratio is 1/3, the mobility of phenol can reach more than 95%.

基金项目：

国家自然科学基金项目（21276146）

作者简介：

第一作者简介：焦潇帅（1994-），男，山东滨州，硕士研究生，研究方向：环境监测与评价，751012795@qq.com 通讯作者简介：王力（1962-），男，博士，教授，研究方向环境与矿物材料， wanglisdust@126.com

参考文献：

[1]王绍文，钱雷. 焦化废水无害化处理与回用技术[M]. 北京：冶金工业出版社，2005:1-4．
[2]Yong-ShikJeong, Jongshik Chung. Simultaneous removel of COD, thiocyanate, cyanide and nitrogen from coal pmcess wastenVater using fluidized biofilm process[J]. Process Biochem, 2006, 41: 1141-1147.
[3]肖敏，周集体，等．均质硅橡胶膜萃取含酚水溶液传质特性研究[J]. 大连理工大学学报，2009, 49(3):333-339．
[4]宋永会，魏健，马印臣，等. 络合萃取技术分离制药废水中的金刚烷胺[J].环境工程学报，2014, 8(10): 4221-4226.
[5]易斌，杨春平，郭俊元，等. 活性炭吸附-Fenton氧化处理高盐有机废水[J].环境工程学报，2013, 7(3): 903-907.
[6]DUARTE F, MORAIS V, MALDONADO F J, et al. Treatment of textile effluents by the heterogeneous Fenton process in a continuous packed -bed reactor using Fe/activated carbon as catalyst[J]. Chem Eng J, 2013, 232(4):34-41.
[7]ARDHENDU S G, ANIMES K G. Fenton, photo-Fcnton, H=O=photolysis, and TiO2 photocatalysis for dipyronc oxidation; drugremoval, mincralization, biodegradability, and degradationmechanism[J]. Ind Eng Chem Res, 2014,53(4): 1351-1358.
[8]Li N. N., Somerset, N. J. Hydrocarbons with Membranes. 1968, US.3410794.
[9]胡萌晓，乔楠楠，常嘉丽，等. 乳化液膜的制备及其在1-萘酚废水处理中的实验研究[J]. 膜科学与技术，2015,35(2):93-97.
[10]CHAOUCHI S，HAMDAOUI O. Removal of 4-nitrophenol from water by emulsion liquid membrane[J]. Desalin Water Treat, 2016,57(12):5253-5257.
[11]CHAOUCHI S，HAMDAOUI O. Extraction of endocrine disrupting compound propylparaben from water by emulsion liquid membrane using trioctylphosphine oxide as carrier[J]. J Ind Eng Chem, 2015,22:296-305.
[12]MA H，KOKKILIC O，WATERS K E. The use of the emulsion liquid membrane technique to remove copper ions from aqueous systems using statistical experimental design[J]. Miner Eng, 2017,107:88-89.
[13]孙玉柱.乳状液膜分离技术的研究进展[[J].湿法冶金，2005, 24 (4): 10-17.
[14]张海燕，庞敏，等. 正辛醇为载体的乳化液膜法脱酚[J].化工进展. 2010,29(12):2400-2404.
[15]柴多里，焦庆周，等.工业酚醛树脂高浓度苯酚废水处理[J].环境污染与防治. 2012,34(11):45-49.
[16]许林妹，张继超.磷酸三丁酯络合萃取苯酚稀水溶液[J]. 江南大学学报. 2008,7(6):737-740.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com